如何做好環氧地坪施工的低溫防范尤其重要
文章出處:無錫寶德萊地坪工程有限公司 發布時間:2018-10-30 21:59:14 瀏覽:15
在環氧地坪施工中,由于環氧地板漆料自身對涂裝環境,譬如溫度,溫度等都有要求,唯有在適合該要求的環境下施工,才調使環氧地坪施工抵達不妨的功效.涂裝環境溫度則合適在10攝氏度以上時最好,低于了這個溫度,則需采用一些改進對策.獨特關于北方的冬天.
In the construction of epoxy floor, because epoxy floor paint itself has requirements for the coating environment, such as temperature, temperature and so on, only in the environment suitable for the requirements of construction, can the epoxy floor construction achieve the desired effect. Advance strategy. Unique winter in the north.
冬天低溫環境下,環氧地坪涂料固化速度變慢,形態變稠密,施工難度也就相應加大,涂料自身品質也相應下落.只管冬天環氧環氧地坪漆施工難度大,品質難保證,但如若工程著實需求在冬天或低溫環境前提下實行,則下面防備對策以便參考.
In winter low temperature environment, the curing speed of epoxy floor coatings becomes slower, the form becomes denser, the construction difficulty increases correspondingly, and the quality of the coatings also drops correspondingly.
盡管避開低溫時段環氧環氧地坪漆施工時,盡管隔斷低溫時段,最好施工時光不妨定為上午10點后到下晝3點之間,盡管節減低溫的波及.增添室溫增添室內溫度,把溫度升高到5度以上,這樣也能夠在冬天施工.北方不少廠房有供暖氣,可在施工前以及施工中開放暖氣供給.
Although avoid the low temperature period of epoxy floor paint construction, although cut off the low temperature period, the best construction time may be set between 10:00 a.m. and 3:00 p.m., although reduce the spread of low temperature. Open heating supply before and during construction.
涂料加熱將涂料安放在溫和的環境,或用蒸汽、熱水實行加熱.但要關注不要讓蒸汽或熱水進路涂料內,而且熱水溫度控制在38度下面.增添溶劑可增添小于5%的揮發速度較快的溶劑,如丙酮、醋酸乙酯、醋酸丁酯等.這樣能夠處理環氧地坪漆在低溫下黏度大,缺乏流平性的問題.
Paint heating places the paint in a mild environment or uses steam or hot water for heating. But be careful not to let steam or hot water enter the paint, and the hot water temperature is controlled below 38 degrees. Adding solvents can increase the volatilization rate of less than 5% faster solvents, such as acetone, ethyl acetate, butyl acetate, etc. Lacquer is very viscous at low temperature and lacks levelling.
隨著頻繁下雨的天氣的到來,環氧地坪施工又遇到了一個新的問題。業內人士都知道環氧地坪漆的施工往往受到天氣溫度的影響。雨天,氣溫過高或過低都會對環氧地坪漆的施工有所影響,空氣中的濕度較大,使得環氧地坪漆的施工也出現了問題,例如發白、氣泡…
水性環氧地坪漆施工方案試驗測試結果以下是水性環氧地坪漆涂料在混凝土試板上做的試驗測試結果。水性環氧地坪漆專用于地下車庫或是沒有做防水處理的潮濕地面使用的,它的施工工藝與普通環氧地坪差不多。水性環氧環氧地坪漆是以乳化型環氧樹脂為主體,以改性聚酰胺為固化劑,根據不同要求…
做環氧地坪漆前如何清除地面油污舊漆及地面有油污不好處理,不徹底處理好,環氧地坪漆工程質量肯定有問題。對地面有油污處理方法通常有以下幾種。1)銑刨機徹底銑除,對薄油污尚可考慮,厚重油污要銑掉很厚一層,銑刀費無法承受,客戶不如重新澆鑄地面。2)局部油污采用火槍燒除,有一…
在環氧地坪施工中,由于環氧地板漆料自身對涂裝環境,譬如溫度,溫度等都有要求,唯有在適合該要求的環境下施工,才調使環氧地坪施工抵達不妨的功效.涂裝環境溫度則合適在10攝氏度以上時最好,低于了這個溫度,則需采用一些改進對策.獨特關于北方的冬天.評論
-
管理員剛剛
暫無任何留言!